Features of grain stocks storage using cooling and monitoring of warehouse pests

  • S. CHernih
  • N. Grekova
  • Yu. CHursіnov
Keywords: grain stocks (reserves), grain storage, cooling, aeration, monitoring, pests density, species composition

Abstract

It was established that the total density and contamination of wheat is higher than in other cultures. On species composition indicators mainly influence conditions and grain storage modes, abiotic factors, use of instrument against pests and protection. Was discussed the possibility of grain aeration under different storage temperature conditions. Was showed an ability to select aeration settings for cooling of grain in elevator siloses. Using of natural cold sources for conservation of grain masses is available and the most cost-effective technique.It is proved that with a temperature of 5–6 degrees grain storage life tripled increases. It was found that it necessary to make cooling in cold and dry weather, with help of aeration or using of active aeration installations. It was found that for cooling it is imperative to determine the weighted average moisture content of grain (on plate or table) and compare with the actual humidity. It is proved that when the actual figure is lower, carry out effective aeration. Was proved, a more efficient way of cooling the grain is the use of the piece-cooled air (performed by apparatus “Kolos500”, HMV-1-30). In many countries air cooling is used to cool the grain with the aim of struggle with pests in grain storage.In research of granaries were mainly studies the following pests: flour mite, common predatory mite, rice weevil, warehouse and grain Shashel. During the research the wheat has a relatively high level of total density of infection and pollution in contrast to other cultures.

References

Довгань С. Зберегли зерно у полі, збережемо і в коморі / С. Довгань, О. Сядриста // Пропозиція. – 2009. – № 2(164). – С. 86–95.

Інтернет ресурс: http: // www.zerno.org.ua/articles

Король. Т. Небезпечність шкідників хлібних запасів / Т. Король, А. Самійленко // Агробізнес сьогодні. – 2006. – № 23 (106). / Т. – С. 24– 28.

Кудіна Ж.Д. Атлас_визначник найбільш небезпечних шкідників запасів / Ж.Д. Кудіна, І.М. Острик, О.В. Башинська. – К.: Укрголовдержкарантин, 2006. – 108 с.

Левченко Е.А. Выявление и количественный учет вредителей хранящегося зерна и продуктов его переработки / Е.А. Левченко // Вредители с.-х. и лесных насаждений. – К.: Урожай, 1989. – Т. 3. – С. 379–383.

Методичні рекомендації з виявлення, обліку шкідливих комах і кліщів та заходи захисту зернових запасів / [Б.О. Терещенко, Г.А. Токарчук, В.Л. Горовий та ін.] – К.: Інститут зернового господарства УААН, 2007. – 37 с.

Методи ентомологічної експертизи продуктів запасу. ДСТУ33-96. – К.: Держстандарт.1996. – С. 4–16.

Черних С.А. Вплив температурного режиму на розвиток комірних шкідників / Черних С.А., Грекова Н.В. // Бюлетень Інституту зернового господарства УААН. – Дніпропетровськ, 2003. – Вип. 20. – С. 25–26.

Бондаренко І.В. Проблема захисту зернових культур при зберіганні в зерносховищах / І.В. Бондаренко // Проблеми відтворення та охорони біорізноманіття України: матеріали Всеукр. науково-практ. конф. (21–22 квітня 2011 р., м. Полтава). – Полтава, 2011. – С. 12–14.

Шемавньов В.І. Практикум з технології зберігання та переробки зерна / В.І. Шемавньов, Н.В. Грекова, О.М. Олексюк. – Дніпропетровськ, 2005. – 200 c.

Машини і обладнання для зберігання та комплексної обробки зерна / [Кобець А.С., Чурсінов Ю.О., Черних С.А., Грекова Н.В.]. – Дніпропетровськ, 2014. – 613 c.

Dovgan, S., Syadristogo, A. (2009). Retained grain in the field, and keep in the pantry. Offer. № 2(164), 86–95.

Online resource: http://www.zerno.org.ua/articles

Korol, T., Samoylenko, A. (2006). The hazard of pests of grain stocks. Agribusiness today. № 23(106), 24–28.

Kudina, G.D., Ostrik, I.M., Bashynsky, A.V. (2006). Atlas of wellknown and most dangerous stocks pests. Kyiv: Ukrgolovderzhkarantyn, 108.

Levchenko, E.A. (1989). Identification and quantitative account of pests of stored grain and products of its processing. Kyiv: Harvest, 3, 379–383.

Tereshenko, B.A., Tokarchuk, G.A., Gorovoy, V.L. et al. (2007). Guidelines for detection, registration harmful insects and mites and measures to protect grain stocks. Kyiv: Institute of grain farming UAAN, 37.

Methods of stock products entomological expertise DSTU33-96. (1996). Kyiv: Dergstandart, 4–16.

Chernyh, S.A., Grekova, N.V. (2003). Effect of temperature conditions on the development of granary pests. Bulletin of the Institute of grain farming UAAN: Dnipropetrovsk. 20, 25–26.

Bondarenko, I.V. (2011). The problem of protecting crops during storage in granaries. Problems restoration and protection of biodiversity Ukraine: Ukrainian scientific-practical conference (April 21–22, 2011, Poltava). Poltava, 12–14.

Shemavn’ov, V.I., Grekova, N.V., Oleksyk, A.M. (2005). Practical work by Technology of storage and processing of grain. Dnepropetrovsk, 200.

Kobets, A.S., Tchursinov, Y.A., Chernyh, S.A., Grekova, N.V. (2014). Machines and equipment for storage and processing of grain complex. Dnipropetrovsk, 613.

Section
Technical sciences